Smoking-Meat.com is supported by its readers. We may earn an affiliate commission at no extra cost to you if you buy through a link on this page.
Read this article without ads
Smoked porchetta (pronounced por-ke’-ta), is an Italian recipe that rolls up a huge piece of pork heavily stuffed with seasoning, herbs, etc., and traditionally includes lots of fennel.
My smoked porchetta recipe is traditional in flavor, but uses the pork belly, the most mouthwatering melt-in-your-mouth cut of pork known to man, and boy is it good!
Let’s get after it!
- Prep Time: 30 minutes
- Dry Brine Time: 12 hours
- Cook Time: ~3 hours
- Smoker Temp: Varies (see instructions below)
- Meat Finish Temp: 200°F (93°C)
- Recommended Wood: Maple, hickory, cherry mix
Back in the day a smoked porchetta was huge, often an entire pig, but for a home cook, that’s a lot, plus, I’m not big on the “whole pig” thing since every part of the pig has different cooking requirements.
In my opinion, the best flavor, texture and tenderness comes from cooking individual parts of the pig to their perfect tenderness using the perfect cooking method for each.
My smoked porchetta is a little different in that I simply use a rolled up pork belly, skin removed.
Most smoked porchetta recipes wrap a pork belly around a pork tenderloin or even part of the loin.
Once again, the leaner tenderloin is done at an internal temperature of 145°F (63°C) while the pork belly is best when cooked all the way to 200°F (93°C) to allow a lot of that fat to render and the meat just melts in your mouth.
Cooking the tenderloin and the belly together means the tenderloin is overcooked and/or the belly is undercooked. Not a good scenario in my humble opinion.
There’s a lot of ways to do things and while I’m not saying my way is the only way, this is the way that turns out the best smoked porchetta at my house.
Here’s How to Make My Smoked Porchetta
Lay the pork belly fat side up.
Use a sharp knife to cut ¼ inch deep crosshatch marks about ¾ inches wide from top to bottom and side to side.
This will help the fat to crisp up a little and give the seasoning and salt a place to grab on to.
Apply a light coat of coarse kosher salt to the crosshatched fat cap. This will help to pull moisture from the fat during the time in the fridge.
I only used about a TBS of coarse kosher salt to the fat cap and some of this will fall off or get wiped off during the process. For this reason, I consider it to be negligible and not part of the salt I use for dry brining the meat side.
Flip the pork belly over to meat side up and do the same crosshatch pattern in the meat about ¼ inch deep and about ¾ inch wide.
I went ahead and cut mine in half to make it more manageable. You can do this at any point in the process or not at all if you’d rather have a smoked porchetta that is full width.
On the meat side, the salt is used for dry brining and almost all of the salt that is applied, will stay put.
In dry brining we typically use ½ teaspoon per pound of meat. I tend to use a little more than this in my own cooking.
My pork belly was 9 lbs and at ½ teaspoons of coarse kosher salt per pound, I need at least 4 and ½ teaspoons or 1-½ TBS.
I rounded up and sprinkled a nice even layer of 2 TBS coarse kosher salt on the meat side of the pork belly.
I also sprinkled on a liberal amount of Jeff’s Texas style rub (Purchase formulas | Purchase bottled product) for good measure.
The belly is now ready for the herb paste.
I removed the leaves from the rosemary and the thicker pieces of thyme and place equal amounts of that into a cheap coffee grinder (works great as an herb grinder.
Note: If the thyme stems are really tender, you can use the stems and leaves together.
I coarse ground up enough rosemary and thyme to make ¼ cup of ground mixture.
I then ground 2 TBS of fennel seed (ended up being about 1 TBS once ground)
Once the herbs and fennel were ground, I placed all of that into a bowl and added enough olive oil to make a spreadable paste. (about ¼ cup of olive eyeballed)
To this mixture, I added 1 TBS of red pepper flakes, 1 TBS of minced garlic and 1 TBS of coarse black pepper.
Mix this all together and if you need more oil to make it spreadable, that’s no problem.
Place half of the herb mixture on each piece of pork belly and spread it out with your hands making sure to get it down in the cuts in the meat.
Man that smells amazing! THIS is a big part of what makes a smoked porchetta so freaking good and that fennel just takes it over the top!
For this part, I recommend a helper if possible.
Roll one half of the pork belly up as tight as you can and tie it with butchers twine about every 1.5 to 2 inches to hold it really tight.
Roll the other half and tie it up just like you did the first one.
Stand there for a minute and take in the beauty of what you just did. Go ahead and lean over and take another whiff of that wonderful aroma if you want to.. you did good!
I decided at the last minute to add a good sprinkling of my original rub (Purchase formulas | Purchase bottled product) on the outside. It works so well on pork!
Place the rolls of tied up pork belly, soon to be smoked porchetta, on a pan with a rack and place the pan into the fridge overnight.
I recommend a full 12 hours if possible. It’s even okay to leave them in the fridge for 24 hours if you want to and have the time.
The next morning, grab the pan of meat from the fridge and place it on the counter while you go get the smoker ready.
Traditional charcoal, wood, gas or electric smoker
Setup your smoker for cooking at 275°F (135°C) using indirect heat. If your smoker uses a water pan, fill up.
Once your smoker is up to temperature, it’s time to cook!
Place the pan of rolled up pork bellies into the smoker and close the door/lid quickly to maintain heat.
Keep a light smoke flowing for the entire time if possible.
Once the pork belly hits 180°F (82°C) or about 2.5 to 3 hours depending on the smoker, weather, etc., it’s time to crisp the fat a little in a higher heat setting.
Note: If you’re looking for a digital meat thermometer, my guide called “6 best digital meat thermometers” will help you decide which one is best for you.
If your smoker/grill can run at a temperature of 450+ or offers a direct heat setup then that’ll work otherwise, it’s best to use a grill or even the oven to finish it up.
Direct charcoal heat such as a kettle, Hasty Bake, Big Green Egg with the plate setter removed, etc. would be perfect for this.
A gas grill will also work okay.
Broil setting on your oven will also work great.
If you’re broiling in the oven, keep a pan under the meat to contain the mess because a lot of fat will render.
Watch the pork bellies while you are crisping the fat so they don’t burn. The idea is to get them on up to 200°F (93°C) internal temperature while also browning and crisping the fat.
Once it’s up to temperature and as brown or blackened as you like, move it to the countertop.
Pellet Smoker
Setup your smoker for cooking at the lowest temperature possible or in the special smoke setting. I used the Camp Chef Woodwind Pro and set it to Lo Smoke.
Once your smoker is up to temperature, it’s time to cook!
Place the pan of rolled up pork bellies into the smoker and close the door/lid quickly to maintain heat.
Hold this Lo Smoke setting for about an hour then crank up the smoker to 300°F (149°C) to finish. The slightly higher heat will offset the time you lost using low heat at the beginning.
Once the pork belly hits 180°F (82°C) or about 2.5 to 3 hours depending on the smoker, weather, etc., it’s time to crisp the fat a little.
I cranked up the temperature on my Campchef Woodwind Pro to 450°F and it only took about 20 minutes to get a good brown on the top side. I rolled the smoked porchetta over to the other side to get some brown on the bottom side.
Another 15 minutes or so and it was perfect.
Once done, remove the smoked porchetta rolls into the house and leave them on the countertop.
Drape a little foil over the top of the smoked porchetta to let them rest for 10-15 minutes before slicing into them.
Slice about ½ inch thick- pause to take a few bites- allow yourself the freedom to say wow and OMG a few times at the amazing flavor and then call the family to help you eat it.
Don’t forget to remove the strings!
We ate the first one gathered around the kitchen island.🤣
Smoked Porchetta
My smoked porchetta recipe is traditional in flavor but uses the pork belly, the most mouthwatering melt-in-your-mouth cut of pork known to man and boy is it good!
Servings: Servings
-
Place the pork belly fat side up and cut a crosshatch pattern in the fatcap ¾ inch wide and ¼ inch deep.
-
Apply about 1 TBS of salt evenly over the entire fat cap.
-
Flip the meat over and cut a crosshatch pattern in the meat ¾ inch wide and ¼ inch deep.
-
Apply about 2 TBS of coarse kosher salt evenly over the entire meat side. Also, sprinkle about 2 TBS of Jeff’s Texas style rub evenly over the entire meat side.
-
Make a paste from 2 TBS ground rosemary, 2 TBS ground thyme, 1 TBS ground fennel, 1 TBS coarse black pepper, 1 TBS minced garlic, 1 TBS red pepper flakes and ¼ cup olive oil. Mix until well combined.
-
Spread the paste over the entire meat side of the pork belly then cut the pork belly in half.
-
Roll each pork belly half tightly then tie every 2 inches with butcher’s twine to hold it secure.
-
Give the outside of the porchettas a good sprinkling of Jeff’s original rub then place them in the fridge overnight.
-
The next day, remove the meat from the fridge and leave it on the counter while you go get the smoker ready.
-
Set up your smoker for cooking at 275°F (135°C) using indirect heat. If your smoker uses a water pan, fill it up.
-
Once the smoker is ready, place the rolled pork bellies on the smoker grate and let them smoke cook at 275°F (135°C) for about 2.5 to 3 hours or until the internal temperature reaches 180°F (82°C).
-
At that point, you can crank up the heat to 450°F+ in a pellet smoker or you can use a charcoal grill or even the broiler on your oven to crisp the fat and bring the porchettas on up to 200°F (93°C) internal temperature.
-
Let the meat rest under tented foil for about 10-15 minutes on the counter, then slice about ½ inch thick and enjoy!
Get Jeff’s Products!
Jeff’s Golden Driller Sauce
$7.99
Jeff’s Original BBQ Sauce
$7.99
Jeff’s Original Rub
$7.99
Jeff’s Texas-style Rub
$7.99
#Smoked #Porchetta #Learn #Smoke #Meat #Jeff #Phillips
